Recent content by rwenzing

$69 for a nickel resistor in a box to make it look like it is more than it is. Sounds like a formula for big profits. This is a commercial version of a cheap hotrodder's trick that has been around for as long as EFI has. All it does is put a resistor in series with the Intake Air Temp sensor to...

The "cap off" light is the precursor to the OBDII code for a relatively large leak in the evaporative emission system. Ford added that light to help avoid a possible EPA-mandated recall action just because a few people left the pump without replacing the fuel cap. Since you have already...

Assuming that the gas cap issue is fixed, all you need to do now is clear the P1000 code. This is accomplished when all of the OBDII monitors complete. Some are quick, others require very strict entry conditions and, depending on your driving habits and route, may take a long time to complete...

You are correct. 98+ 4x4 Rangers have a special version of the D35 up front. The outputs to the halfshafts are 27 spline. Maybe that's the reason for the "27" designation on your tag?

Since your Ranger's EGR only operates at part throttle, it has zero effect on WOT HP or performance. Fuel economy may be VERY slightly improved with the EGR operational because it allows more spark advance. In short, there is nothing to gain by tampering with an EGR system that is in good...

2003 2WD Rangers: 11.28" rotor only. 2003 4x4 Rangers: Mid-model year change from 11.28" rotor (early) to 12" (late). Steering knuckle changed to match. Some accounts put the production changeover at 3/3/2003 but there is some doubt about that date. 2WD rotors include the bearing hub, 4WD do...

On most vehicles, that port would rarely or never be used. Normally, the cap would be removed only as necessary to leak-test the evap system by injecting smoke into it. The usual reason to suspect a leak is a CEL and corresponding trouble code.

The green cap covers the port used to check the fuel tank and evaporative emission system for leaks. Keep it on.

The speedo gear swap only applies to 97 and earlier. OP has a 98. 1998~2000 Ranger Raw VSS source: the ABS sensor on the rear diff housing reads the tone ring. Corrected VSS Wire to speedometer: Gray/Black Adjustment Method: (RABS trucks): flash adjustment in the Generic Electronic...

Both speed control switches should be illuminated but it is not uncommon for the bulb(s) to burn out. Ranger and B-series are brothers under the skin mechanically. Some differences in sheet metal, headlights, taillights, grille and trim. Definitely built on the same assembly line but I couldn't...

The QD's pictured in the first post look similar to 85203 made by www.WarriorProducts.com . They fit 98+ torsion bar Rangers (4x4, Edge and Trailhead). Also fit 95~01 Explorer. About $125/set.

1993 2WD uses an interchangeable cable drive gear at the transmission. Go to the Tech Library at www.therangerstation.com for an article on how to choose the correct gear for your tire and/or axle ratio changes.

Level II Rangers had factory black carpet for a several years but it would be expensive and the Ford part numbers are probably already obsolete. As stated above, check with StockInteriors or you could try www.varkmotors.com . Both sell black carpets and there are other options for backing...

Some of the 2004+ have problems with a small amount of water getting into the SJB and causing any number of weird issues. This could include individual or combination problems involving lights, wiper/washer, windows, locks, radio or anything else timed or powered through the SJB. The symptoms...

Redline Tuning says it will. Their instructions give an alternate location for the upper bracket that allow it to fit.